Jump to content

VK304’s sr20det 88 vanette


Vk304

Recommended Posts

The state of it, I'll be glad when I can stop mowing around these things,- holdens waiting for a driveshaft after my foot slipped on the clutch.., Van's just slowly losing parts  

Today put the fuel tank back in, mostly installed the clutch line and mounted it with rubber bits, quite boring work but takes time.

20201228_170548.jpg

20201228_170425.jpg

20201228_170337.jpg

  • Like 2
Link to comment
Share on other sites

  • Replies 178
  • Created
  • Last Reply

Top Posters In This Topic

  • Vk304

    179

Top Posters In This Topic

I was planning on getting the intake installed today, but the van had other plans... when I installed my starter I realised I hadn't accounted for the space it took up... space my intake was occupying, well- a relocation of the idle circuit, pressure test, and it's good to go, I hope so anyway!

 

20201229_175735.jpg

20201229_175757.jpg

20201229_175812.jpg

20201229_175822.jpg

20201229_175850.jpg

20201229_180059.jpg

  • Like 5
Link to comment
Share on other sites

Another vantatstic day hah, got a lot done.

Had to move this guy a bit as my intake just missed it but when the throttle cable bracket went on it reminded me that space is not my friend here.  No worries though as the radiator hose diddnt like the angle it was on either, so moving the water neck made better space for both.

20201230_200543.jpg

  • Like 3
Link to comment
Share on other sites

A bit of height difference here in the vans, as shown by the radiator.20201230_202353.thumb.jpg.96c06428fa3292e3014a3bf64c390684.jpgwhich used to sit in here20201230_204848.thumb.jpg.1bdd5df5586b8110d545c3bcf62e623a.jpg20201230_200330.thumb.jpg.c5fd546a205d5f0b2cf5969295c3c9d7.jpgso made some brackets that had just enough space behind the crossmember and suspension beam, as well as intercooler mounts...

20201230_200412.jpg

20201230_200435.jpg

That's some more stuff out the way

20201230_200508.jpg

 

 

  • Like 3
Link to comment
Share on other sites

20210103_193534.thumb.jpg.a122e3d1b472bec3be45a88a0f551072.jpgChanged out the cluster to the one from the old van so I've gained a tach, 100,000 less kms and 20 km/h more top speed ..haha, mucked around with the wiring, I'm not so good at it but I guess simple 80s wirings not too bad... 20210103_193650.thumb.jpg.2936dd96b88b8f6133d8f50f56ecbdc5.jpglooks better 20210103_193603.thumb.jpg.c181ca9c5c13fce34942e70b60ededc1.jpgnice labelling still managed to get a wire  wrong though :/ 20210103_193701.thumb.jpg.f5a39b630fcbfdcac4f9d2075a33d797.jpgblew up my alternator somewhere along the way, so I got a spare nissan skyline one and swapped the center out to the silvia housing (housings are different) 

 

20210103_201650.jpg

  • Like 4
Link to comment
Share on other sites

It's now all done and working except for tach, will now just need oil for diff and gearbox, have put water in but needs a flush as heater core is full of rust, no coolant corroded everything, just a couple of things and it will drive!

20210106_131357.jpg

20210106_131420.jpg

  • Like 5
Link to comment
Share on other sites

No where near final but my goal was to have it driving by end of holidays so it's close, of course I diddnt compromise on the quality unless I know I have to buy parts to do it, generally it's just small things that will improve, those will come later 

20210106_174450.jpg

20210106_174407.jpg

  • Like 7
Link to comment
Share on other sites

One more improvement, van had one cracked plastic monsoon shield, my 'luxury' sgl datsun van had stainless shields, so polished them with some autosol and installed. I like the look.

it'll tie in with the rear trim and door slides which are all stainless/chrome plastic .

 

20210108_115358.jpg

20210108_115416.jpg

20210108_115445.jpg

20210108_115700.jpg

20210108_115711.jpg

20210108_115601.jpg

  • Like 5
Link to comment
Share on other sites

Join the conversation

You can post now and register later. If you have an account, sign in now to post with your account.

Guest
Reply to this topic...

×   Pasted as rich text.   Paste as plain text instead

  Only 75 emoji are allowed.

×   Your link has been automatically embedded.   Display as a link instead

×   Your previous content has been restored.   Clear editor

×   You cannot paste images directly. Upload or insert images from URL.

×
×
  • Create New...